Fuel tank and lines of the car Land Rover Freelander 2

Specification of the fuel tank and fuel lines
Fill volume Detail Volume (l/gallons) Fuel tank 68,0/14,9 General specification Detail Specifications Fuel supply module PAG module Location on the right side of the tank Maximum performance at 12.5...

Description and principle of operation
Pos. spare part no Name 1 - Fuel filler cap and cable 2 - Fuel tank filler line 3 - Fuel tank saddle 4 - Fuel tank 5 - Exhaust heat shield 6 - Fuel line protection chute under the floor 7 - Fuel...

Fuel tank design
The fuel tank has a usable capacity of 68.0 litres, and has a burn out strategy to prevent air from entering the high pressure fuel system. The tank is made of six-layer laminated plastic by blow...

Fuel tank internals
Pos. spare part no Name 1 - Fuel tank vent valve 2 - cross pipeline 3 - Coarse filter 4 - Fuel level sensor float (2 pcs.) 5 - MAPPS type fuel gauge sensor (magnetic passive position sensor) (2 pcs.)...

Fuel tank filling neck
Pos. spare part no Name 1 - Filler cap and cable 2 - External tank vent hose 3 - filler hose 4 - Filler pipe The fuel tank is filled through an aluminum filler neck, which is connected via a rubber...

Supply and return lines
Pos. spare part no Name 1 - Rear access cover 2 - Quick Connector (4 things.) 3 - Fuel return line 4 - Front access cover 5 - Fuel supply line 6 - Protective chute running under the floor The supply...

Fuel filter assembly
Pos. spare part no Name 1 - Fuel temperature sensor 2 - Fuel supply to the high pressure pump 3 - Condensate drain screw 4 - Fuel filter 5 - Fuel filter shield 6 - Condensate drain port 7 - Fuel...

Inspection and verification
CAUTION: Diagnosis by substituting a component from another vehicle is NOT allowed. The substitution of control units does not guarantee confirmation of the fault and, moreover, may cause additional...

Table of fault signs
Symptom Possible reason Action Engine cranks but won't start Low/contaminated fuel Air intake leak Fuel system leak, blockage/clogging Electronic engine controls Check for low/contaminated fuel Check...

DTC Fault Code Index
NOTE: If a module or component is suspected and the vehicle continues to be covered by the manufacturer's warranty, refer to the warranty manual before installing a new module/component (subsection...

Removal and installation of the fuel tank
Special tool 310-123 Locking Ring, Fuel Tank General Equipment: Powertrain Jack Fuel may still remain in the fuel tank after draining. Avoid open source of flame, sparks or flammable substances....

Fuel level sensor
NOTE: The description of the removal procedure in this manual may include installation steps. Removing 1. Disconnect the battery ground wire. Refer to procedure: Specifications (414-00 Charging...

Fuel tank filler pipe
NOTE: The description of the removal procedure in this manual may include installation steps. Removing 1. Raise and support the vehicle. WARNING: It is forbidden to carry out work on a vehicle...

Fuel filter
After stopping the engine, wait at least one minute before making any repairs to the fuel injection system. Avoid open flames, sparks or flammable substances. Prepare to collect spilled fuel....

Fuel pump and fuel delivery unit
NOTE: The description of the removal procedure in this manual may include installation steps. Removing 1. Disconnect the battery ground wire. Refer to procedure: Specifications (414-00 Charging...